Carolina Pulled Pork Sandwiches Recipes

Steps:

• Make small holes all over the pork shoulder with a thin sharp knife and stuff in garlic cloves. Rub the meat all over with the Memphis Shake; cover and refrigerate overnight.
• Prepare an outdoor grill with an indirect medium-hot fire with a mix of briquettes and hardwood charcoal in half of the grill. Set grate over coals. Place pork, skin side up, in an aluminum pan with about 1 1/2 cups water on the cooler side of the grate. Toss 1 cup of the soaked and drained wood chips onto the coals and cover the grill, making sure the lid's vents are directly over pork.
• When the coals cool to medium-low heat, preheat a chimney-full of hot briquettes and hardwood charcoal. Whenever smoke stops coming out of the vents, about every hour, add more hot coals and 1 cup of soaked and drained wood chips to the fire. The goal is to maintain a medium-heat, smoky fire (but don't worry if it is hotter when the coals are added and cooler while preheating the coals). Rotate the pork when you add coals so it cooks evenly. Cook the meat until an instant-read thermometer inserted into the thickest part of the pork registers 180 degrees F, about 6 hours.
• Set aside 1 quart of the North Carolina-Style Vinegar BBQ Sauce. Once the pork reaches 180 degrees F, begin mopping the entire surface of the meat every 20 minutes with some of the remaining sauce and the pan drippings. Continue to cook the pork, covering the grill between mopping, until an instant-read thermometer registers 200 degrees F, about 1 to 2 hours more.
• Transfer the pork to a cutting board and let rest for at least 15 minutes. Remove the outer skin and discard. Cut large chunks from the bone and shred, using 2 forks or your fingers, (when cool enough to touch) or chop. Toss with about 1 cup of the reserved barbecue sauce for every 3 cups of meat. Tuck the pork into the soft rolls and serve with pickles.
• Whisk paprika, brown sugar, oregano, garlic, ancho powder, salt, and celery salt in a small bowl. Store in an airtight container in a cool, dry place for up to 2 months.
• Heat the vinegar and sugar in a medium saucepan over medium heat until the sugar dissolves. Off the heat, stir in the ketchup, honey, salt, red pepper, and black pepper.

Steps:

• In a small bowl, mix mild paprika, light brown sugar, hot paprika, celery salt, garlic salt, dry mustard, ground black pepper, onion powder, and salt. Rub spice mixture into the roast on all sides. Wrap in plastic wrap, and refrigerate 8 hours, or overnight.
• Prepare a grill for indirect heat.
• Sprinkle a handful of soaked wood over coals, or place in the smoker box of a gas grill. Place pork butt roast on the grate over a drip pan. Cover grill, and cook pork until pork is tender and shreds easily, about 6 hours. Check hourly, adding fresh coals and hickory chips as necessary to maintain heat and smoke.
• Remove pork from heat and place on a cutting board. Allow the meat to cool approximately 15 minutes, then shred into bite-sized pieces using two forks. This requires patience.
• In a medium bowl, whisk together cider vinegar, water, ketchup, brown sugar, salt, red pepper flakes, black pepper, and white pepper. Continue whisking until brown sugar and salt have dissolved. Place shredded pork and vinegar sauce in a large roasting pan, and stir to coat pork. Serve immediately, or cover and keep warm on the grill for up to one hour until serving.

Steps:

• The Meat --.
• Place the quartered onions in a crock pot.
• Combine brown sugar, paprika, salt and pepper: rub over the roast.
• Place the roast over the onions in the crock pot.
• Combine the vinegar, Worcestershire Sauce, red pepper flakes, sugar, mustard, garlic salt and cayenne; stir to mix well.
• Drizzle about 1/2 of the vinegar mixture over the roast and cover. Refrigerate the remaining vinegar mixture.
• Cook on low for 8 hours. Drizzle the other half of the vinegar mixture over the roast during the last 1/2 hour of cooking.
• While the meat is cooking, prepare the barbecue sauce. Mix all ingredients except soy sauce, butter and smoke. Simmer, uncovered, on low heat for 30 minutes. Stir in the remaining ingredients and simmer, uncovered, for 10 more minutes. Set aside to cool.
• Remove the meat from the crock pot and allow to rest for at least 15 minutes. (Very important step -- longer is better).
• Remove the onions and chop to a fine consistency.
• Pull apart the meat with a couple of forks. Meat should have a shredded look to it.
• Mix chopped onions and shredded pork along with a little bit of juice from the crock pot to taste. Add sufficient barbecue sauce to the mixture to achieve desired taste. Meat should have distinctive barbecue flavor.
• To serve, spread barbecue sauce on bottom of a hearty bun.
• Put layer of pulled pork on bun. Spread barbecue sauce over meat.
• Add layer of your favorite cole slaw on top of meat. Layer some more barbecue sauce over cole slaw.
• Spread top of bun with more sauce.
• Grab a fist full of napkins, and enjoy.

Steps:

• Rinse and dry the pork shoulder. Let rest at room temperature for 1 1/2 hours. In a small bowl, combine black pepper, paprika, garlic powder, onion powder, salt, chili powder, cumin, brown sugar, dry mustard and cayenne. Rub mixture all over the pork.
• Arrange the oven racks in the middle and lower parts of the oven and preheat to 225 degrees F. Put a sheet tray on the lower rack and the pork directly on the middle rack, uncovered. Put the cast iron pan with the hickory chips on the floor of the oven. Remove the chips after 2 hours of cook time. The entire cooking time will be 8 to 10 hours.
• Apply Mop Sauce every hour throughout the cooking time.
• In the last hour of cook time, remove pork, wrap it tightly in plastic wrap, and then in aluminum foil and return to the oven for 1 more hour. Remove the pork from the oven to a work surface. Let rest until cool enough to pull the pork from the bones.
• To serve, cut the buns in half and pile up some pulled pork. Top with the Vinegar Sauce, then a large spoonful of the Fo Slaw and a final spoonful of sauce. Cover with the bun top and serve.
• Mop Sauce:
• Combine all the ingredients in a medium bowl and reserve.
• In a large saucepan, mix together all the ingredients, in the order given, over low heat. Simmer for 30 minutes.
• Recipe courtesy Ed Wilson, Wilson's Holy Smoked BBQ
• Combine all the dressing ingredients together in a large bowl. Adjust seasonings, if necessary. Add the cabbage and the carrots and toss to coat. Cover with plastic wrap and refrigerate for 1 hour.

Steps:

• Bring vinegar to a boil with sugar, red-pepper flakes, 2 tsp salt, and 1 Tbsp pepper in a small nonreactive saucepan, stirring until sugar has dissolved, then cool. Set aside 2 cups vinegar sauce to serve with sandwiches.
• While sauce cools, score pork skin in a crosshatch pattern with a sharp knife (forming 1-inch diamonds), cutting through skin and fat but not into meat. Pat meat dry and rub all over with 1 Tbsp each of salt and pepper. Let stand at room temperature 1 hour before grilling.
• Prepare grill for indirect-heat cooking over low heat, leaving space in middle for disposable roasting pan.
• When coals have cooled to about 300°F (45 minutes to 1 hour; when most coals will have burned out), put disposable roasting pan on bottom rack of grill between the 2 remaining mounds of coals, then fill pan halfway with water. Add a couple of handfuls of unlit charcoal to each charcoal mound, then put grill rack on so hinges are over coals.
• Oil grill rack, then put pork, skin side up, on rack above roasting pan. Grill pork, with lid ajar (for air, so coals remain lit), basting meat with sauce and turning over every 30 minutes (to maintain a temperature of 250 to 275°F, add a couple of handfuls of coals to each side about every 30 minutes), until fork-tender (a meat fork should insert easily) and an instant-read thermometer inserted 2 inches into center of meat (avoid bone) registers 190°F, 7 to 8 hours total.
• Transfer pork to a cutting board. If skin is not crisp, cut it off with at least 1/4 inch fat attached (cut any large pieces into bite-size ones) and roast, fat side down, in a 4-sided sheet pan in a 350°F oven until crisp, 15 to 20 minutes.
• When meat is cool enough to handle, shred it using 2 forks. Transfer to a bowl.
• Serve pork, cracklings, and coleslaw together on buns. Serve reserved vinegar sauce on the side.

Steps:

• Spray 3- to 4-quart slow cooker with cooking spray. Trim fat from pork; place in cooker. In small bowl, mix brown sugar, salt, pepper and paprika; rub over pork.
• In medium bowl, mix remaining ingredients except rolls and coleslaw; pour into slow cooker.
• Cover; cook on Low heat setting 8 to 9 hours.
• Remove pork from cooker; place on cutting board. Shred pork with 2 forks; return to cooker and mix well.
• Using slotted spoon, spoon about 1/2 cup pork mixture, on bottom half of each roll. Top each with about 2 tablespoons coleslaw. Cover with top halves of rolls. Pork mixture can be kept warm on Low heat setting up to 2 hours; stir occasionally.